PLEASE PATRONIZE OUR SPONSORS!
#1
|
|||
|
|||
782 getting hot
Hey guys, I have been busy using my 782 I picked up last fall.
Recently it started to surge after it gets hot. I will mow for awhile and it it it start surging until it dies. Then I can restart it and get another 10 mins out of it until it dies again. I have found if I let it cool off it will run great. A few days ago I decided to take the side panels off to see it that would help with the heat. Sure enough I haven't had a problem since. What gives? What's the surging from? Vapor lock? How do I get that to go away so I can put the side panels back on and mow on a hot day? |
#2
|
|||
|
|||
And because no thread is any good without pics..
|
#3
|
||||
|
||||
The blower housing on the engine could possibly be filled with mouse nest.
__________________
Tim Pap's 100 Restored 108 1211 Dual Stick 1050 Pap's 100 restoration thread - http://onlycubcadets.net/forum/showthread.php?t=47965 |
#4
|
|||
|
|||
Ok, I'll tear it down this weekend. And report back if I find anything.
|
#5
|
||||
|
||||
Yep, give 'er a good blowdown. They need to have a lot of airflow to stay cool. Hopefully that's all it is.
__________________
Daniel G. . (May 1970) 147 w/an IH spring assist, 48" deck, 42" blade, 1969 73, #2 trailer, 10" Brinly plow and (on loan) Dad's #2 tiller. |
#6
|
|||
|
|||
My 782 acted very similar. Dying when it would get hot, then start back up when it cooled off. When I tried to start it when it was hot, it didn't have any spark.
I replaced the coil. I haven't had any issues since. |
#7
|
|||
|
|||
No mouse nests to be seen. It's been running better, but it's been cooler and I have been keeping the throttle down as well.
|
#8
|
||||
|
||||
You want to mow at WOT (wide open throttle) as that not only gives you the best blade tip speed but also gives you better cooling for your engine. They were designed to operate at that RPM for mowing, take advantage of that
__________________
-Ryan
|
#9
|
|||
|
|||
Well I get that, but it is run it at 3/4 throttle or mow and sit and wait....
|
#10
|
||||
|
||||
Richen the top end.
__________________
Terry O,100,72,102,123,104,124,105 125,129,149,1200,982 (2)2182s w/60in Habans 3225 |
|
|
Cub Cadet is a premium line of outdoor power equipment, established in 1961 as part of International Harvester. During the 1960s, IH initiated an entirely new line of lawn and garden equipment aimed at the owners rural homes with large yards and private gardens. There were a wide variety of Cub Cadet branded and after-market attachments available; including mowers, blades, snow blowers, front loaders, plows, carts, etc. Cub Cadet advertising at that time harped on their thorough testing by "boys - acknowledged by many as the world's worst destructive force!". Cub Cadets became known for their dependability and rugged construction.
MTD Products, Inc. of Cleveland, Ohio purchased the Cub Cadet brand from International Harvester in 1981. Cub Cadet was held as a wholly owned subsidiary for many years following this acquisition, which allowed them to operate independently. Recently, MTD has taken a more aggressive role and integrated Cub Cadet into its other lines of power equipment.
This website and forum are not affiliated with or sponsored by MTD Products Inc, which owns the CUB CADET trademarks. It is not an official MTD Products Inc, website, and MTD Products Inc, is not responsible for any of its content. The official MTD Products Inc, website can be found at: http://www.mtdproducts.com. The information and opinions expressed on this website are the responsibility of the website's owner and/or it's members, and do not represent the opinions of MTD Products Inc. IH, INTERNATIONAL HARVESTER are registered trademark of CNH America LLC
All material, images, and graphics from this site are the property of www.onlycubcadets.net. Any unauthorized use, reproductions, or duplications are prohibited unless solely expressed in writing.
Cub Cadet, Cub, Cadet, IH, MTD, Parts, Tractors, Tractor, International Harvester, Lawn, Garden, Lawn Mower, Kohler, garden tractor equipment, lawn garden tractors, antique garden tractors, garden tractor, PTO, parts, online, Original, 70, 71, 72, 73, 76, SO76, 80, 81, 86, 100, 102, 104, 105, 106, 107, 108,109, 122, 123, 124, 125, 126, 127, 128, 129, 147, 149, 169, 182, 282, 382, 482, 580, 582, 582 Special, 680, 682, 782, 782D, 784, 800, 805, 882, 982, 984, 986, 1000, 1015, 1100, 1105, 1110, 1200, 1250, 1282, 1450, 1512, 1604, 1605, 1606, 1610, 1615, 1620, 1650, 1710, 1711, 1712, 1806, 1810, 1811, 1812, 1912, 1914.